idw – Informationsdienst Wissenschaft
Nachrichten, Termine, Experten
Nachrichten, Termine, Experten
Worldwide, discarded electronic toys, computers, or smartphones are becoming increasingly massive amounts of electronic waste. The basis for electronic circuits are printed circuit boards (PCB), which are typically made of glass fiber-reinforced fossil epoxy resin, making them difficult to recycle, let alone biodegrade. A team from TU Bergakademie Freiberg has now presented a fully compostable alternative made from the mycelium of the Aspergillus niger fungus, a byproduct of industrial citric acid production.
Instead of disposing of this biomass waste, the team processes it into a plastic-like material through an innovative process involving molding and air-drying, resulting in a small, approximately 0.5 cm thick plate with a density of 1.23 g/cm³, comparable to the density of conventional printed circuit boards (PCBs). Using direct ink writing or a standard etching process and manual soldering, the researchers were able to deposit electronic components directly onto the fungal plates.
"In laboratory tests, the material from fungal mycelium shows high mechanical properties and good heat stability," explained Nina Oehlsen, a doctoral student at the TU Bergakademie Freiberg and first author of the scientific publication. "Although the electrical properties are still below those of standard PCBs, fungal mycelium is sufficient for prototype or low-frequency applications - such as environmental sensors, consumer goods, and toys."
However, in order for the plate to be comparable to current PCBs, it must be tested according to standards such as IPC-A-600 or DIN EN 60249-1 and optimized in terms of its water absorption.
Challenges in End-of-Life Management
By 2030, an estimated 82 million tons of electronic waste are expected worldwide, according to the "Global E-waste Monitor" (https://ewastemonitor.info/the-global-e-waste-monitor-2024/). The sustainable circuit board, named AnimatPCB, addresses not only the environmental burden of non-recyclable e-waste but also offers a solution for the avoidance of non-reusable materials at the end of life of the circuit boards. The circuit board itself is fully biodegradable, and the transistors deposited on it could be functionally recovered, said Linus Stegbauer, junior professor for biogenic technical materials at the TU Bergakademie Freiberg: "We have created a high-quality, functional material from an industrial waste product - without additional fossil raw materials. In comparison to a conventional circuit board, fungal mycelium has up to 56% lower CO2 footprint and can be easily and safely dissolved in water at the end of its life."
The bio-inspired research can make a significant contribution to the development of a circular electronics industry: "We demonstrate that it is possible to develop high-quality electronic components without long-term environmental burden - and show solutions for a circular electronics industry," emphasizes Professor Simon Glöser-Chahoud, an economist at the TU Bergakademie Freiberg, who calculated the CO2 footprint over the entire life cycle of the innovative material.
Jun.-Prof. Dr. rer. nat. Linus Stegbauer
linus.stegbauer@esm.tu-freiberg.de
Original publication: From biotechnological residues to biodegradable printed circuit boards: Aspergillus niger mycelium as a structural support material, Cleaner Materials, https://doi.org/10.1016/j.clema.2026.100416
Junior Professor Linus Stegbauer shows a sample of the fungal mycelium powder that has been dried an ...
Source: Andreas Hiekel
Copyright: TU Bergakademie Freiberg / A. Hiekel
Functional prototype of the fungal mycelium circuit board. After use, the circuit board can be compo ...
Source: Andreas Hiekel
Copyright: TU Bergakademie Freiberg / A. Hiekel
Criteria of this press release:
Journalists
Electrical engineering, Environment / ecology, Materials sciences
transregional, national
Research results
English
Junior Professor Linus Stegbauer shows a sample of the fungal mycelium powder that has been dried an ...
Source: Andreas Hiekel
Copyright: TU Bergakademie Freiberg / A. Hiekel
Functional prototype of the fungal mycelium circuit board. After use, the circuit board can be compo ...
Source: Andreas Hiekel
Copyright: TU Bergakademie Freiberg / A. Hiekel
You can combine search terms with and, or and/or not, e.g. Philo not logy.
You can use brackets to separate combinations from each other, e.g. (Philo not logy) or (Psycho and logy).
Coherent groups of words will be located as complete phrases if you put them into quotation marks, e.g. “Federal Republic of Germany”.
You can also use the advanced search without entering search terms. It will then follow the criteria you have selected (e.g. country or subject area).
If you have not selected any criteria in a given category, the entire category will be searched (e.g. all subject areas or all countries).
