idw – Informationsdienst Wissenschaft
Nachrichten, Termine, Experten
Nachrichten, Termine, Experten
The use of industrial waste heat can develop into an important component of an energy industry that is independent of fossil fuels. To convert large amounts of waste heat into electricity as efficiently as possible, turbines with a high degree of efficiency are required that work with a special conversion process – the Organic Rankine Cycle (ORC). In a pilot project for the development of such a turbine, the Center of Energy Technology (ZET) of the University of Bayreuth is cooperating with TGM Kanis Turbinen GmbH in Nuremberg. The Bavarian State Ministry of Economic Affairs, Regional Development and Energy is funding the project for three years with a total of about 1.7 million euros.
In most cases, the heat generated by industrial production processes is still released into the environment and thus into the atmosphere. If this waste heat were to be used on a large scale to generate electricity, this would make a significant contribution to climate protection and a sustainable energy industry. However, the temperatures of the waste heat generated by industrial plants depend on the respective industrial processes; they are usually between 100 and 500 degrees Celsius. The waste heat can therefore only be converted into electricity with the help of the Organic Rankine Cycle (ORC). In this process, an organic fluid with a low boiling point is used instead of water. In this way, turbines can be used efficiently to generate electricity even below 300 degrees Celsius.
Previous research work, in which the Center of Energy Technology (ZET) at the University of Bayreuth was involved, among others, has shown: When converting large amounts of industrial waste heat into electricity, a particularly high degree of efficiency is advantageous. The Nuremberg-based company TGM Kanis Turbinen GmbH now wants to apply the experience it has gained so far in steam applications to the development of a turbine with improved efficiency. The findings are to be transferred to the conversion of industrial waste heat in the new project, which is being funded by the Bavarian Ministry of Economic Affairs, Regional Development and Energy from the Bavarian Energy Research Programme. A corresponding ORC turbine is therefore to be built at the Nuremberg site. This is to be scalable up to a capacity of ten electrical megawatts (MWel).
The Center of Energy Technology (ZET) of the University of Bayreuth, which has extensive experience in operating geothermal ORC test plants on the Bayreuth campus, will support and drive the pilot project with its scientific expertise: It is responsible for the conception and design of the test stand, corresponding process simulations, and scientific monitoring of the plant's operation. A Bayreuth master's student from the Faculty of Engineering is also involved in the project from the outset. In his thesis, he will deal specifically with process simulation and the initial design of the plant. Further student work is already firmly scheduled.
Dr.-Ing. Florian Heberle
Senior research associate | ZET Managing Director
Technical Thermodynamics and Transport Processes (LTTT)
Center of Energy Technology (ZET)
University of Bayreuth
Phone: ++49 (0)921 / 55-6803 and 55-7163
E-mail: florian.heberle@uni-bayreuth.de
Meeting for the project launch in Nuremberg at TGM Kanis Turbinen GmbH, from left: Dr. Gösta Pretel ...
(c) TGM Kanis.
Steam reaction turbine of TGM Kanis Turbinen GmbH with an output of up to 10 MWel.
(c) TGM Kanis.
Merkmale dieser Pressemitteilung:
Journalisten, Lehrer/Schüler, Studierende, Wirtschaftsvertreter, Wissenschaftler, jedermann
Energie, Maschinenbau
überregional
Forschungsprojekte, Kooperationen
Englisch
Meeting for the project launch in Nuremberg at TGM Kanis Turbinen GmbH, from left: Dr. Gösta Pretel ...
(c) TGM Kanis.
Steam reaction turbine of TGM Kanis Turbinen GmbH with an output of up to 10 MWel.
(c) TGM Kanis.
Sie können Suchbegriffe mit und, oder und / oder nicht verknüpfen, z. B. Philo nicht logie.
Verknüpfungen können Sie mit Klammern voneinander trennen, z. B. (Philo nicht logie) oder (Psycho und logie).
Zusammenhängende Worte werden als Wortgruppe gesucht, wenn Sie sie in Anführungsstriche setzen, z. B. „Bundesrepublik Deutschland“.
Die Erweiterte Suche können Sie auch nutzen, ohne Suchbegriffe einzugeben. Sie orientiert sich dann an den Kriterien, die Sie ausgewählt haben (z. B. nach dem Land oder dem Sachgebiet).
Haben Sie in einer Kategorie kein Kriterium ausgewählt, wird die gesamte Kategorie durchsucht (z.B. alle Sachgebiete oder alle Länder).
